| Violation Item
| Demerits
| Violation Description
| CDI | R | VR |
|
|---|
|
6
|
0
|
Proper eating, tasting, drinking or tobacco use |
No |
No
|
No |
2-401.11 (A). Employee beverages must be stored in a designated area where contamination of food, clean equipment, utensils, linens, and single-use articles cannot occur.
Observed an employee's drink store on shelf inside the WIC, commingled with consumer food.
Store all employee beverages in a manner where they cannot contaminate food for sale. |
|
10
|
1
|
Handwashing sinks supplied & accessible |
Yes |
No
|
No |
6-301.12 Provide paper towels or approved alternative for hand drying at each handsink. -Pf
Observed no paper towels available at the back handsink.
CDI: PIC provided roll of paper towels for handsink. |
|
16
|
1.50
|
Food-contact surfaces: cleaned & sanitized |
Yes |
No
|
No |
4-501.114 Maintain sanitizer at correct concentrations when being used to sanitize. -P
Observed chlorine sanitizer measuring low concentration, below 50ppm at the 3-compartment sink.
CDI: PIC added more chlorine sanitizer and EHS observed it was measuring above 100ppm.
For more information please visit: https://health.mecknc.gov/envhealth/food-and-facilities-sanitation or view our training videos at the following weblinks: Sanitizing Solutions - https://youtu.be/ykP2mr9CtRg and How to Test Sanitizer https://youtu.be/y0SjmnabFaY |
|
23
|
0
|
Proper date marking & disposition |
Yes |
No
|
No |
3-501.17 (A) or (B) Date mark/label all TCS foods that are ready-to-eat once opened or prepared and are to be held for more than 24 hours. -Pf. Establish a date marking system consistent with 3-501.17 (A) or (B). Additional date marking system options are found in 3-501.17 (D).
Observed pan of sliced tomatoes and portioned bags of hotdogs both stored inside the make table without date labels. PIC stated hotdogs were just placed to cool down a few hours prior, and tomatoes were prepared during third shift last night.
CDI: PIC created date labels for both TCS food items.
For more information, please visit: www.mecknc.gov/foodsafety or view our training videos at the following weblinks: What are TCS Foods https://www.youtube.com/watch?v=q0iLZb7v0UM and Date Marking Food Safely https://youtu.be/BOPsSNUajYs . |
|
33
|
0.50
|
Proper cooling methods used; adequate equipment for temperature control |
Yes |
No
|
No |
3-501.15 Quickly cool foods. Use methods such as open/vented shallow pans, large ice baths and active stirring. Cold air must flow around product to remove the heat. -Pf
Observed portioned bags of hotdogs unable to meet the cooling rate. Hotdogs were stored inside the lowboy portion of the make table. PIC stated these were prepared about two hours prior.
CDI: PIC movved bags of hotdogs into the WIF to rapidly cool down.
For more information, please visit: https://health.mecknc.gov/envhealth/food-and-facilities-sanitation or view our training videos at the following weblinks: What are TCS Foods https://youtu.be/bRvqAETDjQU and Cooling Food Safely https://youtu.be/P6x8b1ZVOxU . |
|
43
|
0
|
In-use utensils: properly stored |
No |
No
|
No |
3-304.12 (B) In-use utensils for food that is not TCS must be stored with their handles above the top of the food within containers or equipment that can be closed.
Observed large scoop handle stored inside chicken breading flour, commingled inside the food product.
Ensure all scoop handles are stored above the top of the food product to prevent contamination. |
|
44
|
0
|
Utensils, equipment & linens: properly stored, dried & handled |
No |
No
|
No |
4-903.11 (B) After cleaning and sanitizing, clean equipment and utensils shall be stored in a self-draining position that allows air drying and covered or inverted.
Observed multiple stacks of wet-stacked pans stored on the clean dish rack.
Allow all multi-use utensils and equipment to completely air-dry before stacking together. |
|
49
|
0.50
|
Non-food contact surfaces clean |
No |
Yes
|
No |
4-601.11(C ) Keep non food contact surfaces of equipment clean to avoid build up of dust, food residue or debris.4-602.13 Non food contact surfaces of equipment shall be cleaned frequently to preclude accumulation of soil residues.
Observed heavy buildup on gasket on the left corner of the HH case 2, preventing easy open and close. Observed heavy buildup on hood system. Observed dust and debris buildup on shelves throughout the facility.
Increase cleaning frequency.
REPEAT VIOLATION. |
|
55
|
1
|
Physical facilities installed, maintained & clean |
No |
Yes
|
No |
6-501.12 Floors, walls, ceilings including the attachments such as soap, towel dispensers; light fixtures; and heat/ac vent covers shall be clean. Caution should be used to minimize food exposure.
Observed wall next to make table soiled with food debris. Observed wall behind dry food storage racks soiled with food residues.
Increase cleaning frequency.
REPEAT VIOLATION. |