| Violation Item
| Demerits
| Violation Description
| CDI | R | VR |
|
|---|
|
16
|
1.50
|
Food-contact surfaces: cleaned & sanitized |
Yes |
No
|
No |
4-601.11(A) Equipment food contact surfaces and utensils shall be clean to sight and touch. -Pf. For more information please visit: http://meck.co/FoodSafety or view our training videos at the following weblinks: Sanitizing Solutions - https://youtu.be/ykP2mr9CtRg , How to Test Sanitizer https://youtu.be/y0SjmnabFaY , and Cleaning and Sanitizing Food Contact Surfaces https://youtu.be/av1Rbh-lh08 . Observed buildup on table mounted can opener tooth. CDI - PIC cleaned. -1.5- |
|
33
|
1
|
Proper cooling methods used; adequate equipment for temperature control |
Yes |
No
|
No |
3-501.15 Quickly cool foods. Use methods such as open/vented shallow pans, large ice baths and active stirring. Cold air must flow around product to remove the heat. -Pf For more information please visit: http://meck.co/FoodSafety or view our training videos at the following weblinks: What are TCS Foods https://youtu.be/bRvqAETDjQU and Cooling Food Safely https://youtu.be/P6x8b1ZVOxU . Observed overstacked, deep plastic bins of cooked house made pickle, house made pork sauce cooling in walk in cooler with lid in place. Per PIC, these products are actively stirred every 30 minutes and actively stirred. CDI - PIC instructed portions reduced into several smaller containers. -1- THIS IS THE SECOND CONSECUTIVE INSPECTION WITH MAXIMUM POINT DEDUCTION. A RISK CONTROL PLAN WILL BE REQUIRED IF THE METHOD IS OBSERVED AGAIN THAT DOES NOT FACILITATE ACTIVE COOLING. -1- |
|
38
|
0
|
Insects & rodents not present; no unauthorized animals |
No |
Yes
|
No |
6-202.15 Protect outer openings of establishment from insect or rodent entry. Observed main roll up door open at beginning of inspection. CDI - PIC closed roll up door and EHS reminded PIC about the requirement to protect outer openings. REPEAT -0- POINTS NOT ESCALATED TODAY AS THE CONDITION WAS MUCH IMPROVED OVER LAST INSPECTION. |
|
40
|
0
|
Personal cleanliness |
No |
No
|
No |
2-402.11 Use head coverings, beard guards and clothing to restrain body hair from contacting exposed food, equipment, and utensils. Observed no hair restraint on three food employees cooking and washing dishes. -0- |
|
44
|
0
|
Utensils, equipment & linens: properly stored, dried & handled |
No |
No
|
No |
4-901.11(A) Air dry equipment and utensils after cleaning and sanitizing. Observed wet nested measuring cups on drying shelf. Allow air drying before stacking. -0- |
|
47
|
0
|
Equipment, food & non-food contact surfaces approved, cleanable, properly designed, constructed & used |
No |
No
|
No |
4-202.11 Multiuse food contact surfaces shall be smooth, free of open seams, cracks, chips, pits, sharp internal angles, crevices and assembled to allow access to clean. -Pf Observed pitted and cracked rubber spatulas and ice scoops. CDI - PIC voluntarily discarded. -0- |
|
48
|
0
|
Warewashing facilities: installed, maintained & used; test strips |
No |
No
|
No |
4-501.19 During manual warewashing, maintain the wash solution at a minimum of 110F or as otherwise allowed by the detergent manufacturer label. -Pf Observed manual warewashing in wash water at 101F. CDI - PIC refilled with hot water at 149F. -0- |
|
51
|
0
|
Plumbing installed; proper backflow devices |
Yes |
No
|
No |
5-205.15 Maintain a plumbing system in good repair. Observed leak at faucet on 3-comp sink. Colder water leaking into wash water. CDI - PIC has submitted repair order. -0- |
|
55
|
0.50
|
Physical facilities installed, maintained & clean |
No |
Yes
|
No |
6-501.11 Floors, walls, and ceilings including the attachments such as soap and towel dispensers; light fixtures; and heat/ac vents shall be maintained in good repair. Observed rack for hanging pots and utensils falling off wall over 3-comp sink. REPEAT -.5- |