| Violation Item
| Demerits
| Violation Description
| CDI | R | VR |
|
|---|
|
14
|
1.50
|
Food-contact surfaces: cleaned and sanitized |
No |
Yes
|
No |
4-501.114 Maintain sanitizer at correct concentrations when being used to sanitize. -P- Observed sanitizer bucket, at prep sink, QUAT sanitizer concentration at 50PPM. CDI- PIC had employee change that bucket to 200ppm QUAT.
4-601.11(A) Equipment food contact surfaces and utensils shall be clean to sight and touch. -Pf- Observed several pans with sticker residue stack together and stored clean. |
|
19
|
0
|
Proper hot holding temperatures |
Yes |
No
|
No |
3-501.16(A)(1) Maintain TCS foods in hot holding at 135F or above. -P- Observed cooked eggs hot holding at 120F. CDI- PIC voluntarily discarded the item. |
|
31
|
0.50
|
Proper cooling methods used; adequate equipment for temperature control |
Yes |
No
|
No |
3-501.15 Quickly cool foods. Use methods such as open/vented shallow pans, large ice baths and active stirring. Cold air must flow around product to remove the heat. -Pf- Observed diced chicken cooling in the walk in at 52F and tightly covered. CDI- Employee uncovered the item to allow air to quickly flow through the product. |
|
36
|
0
|
Insects and rodents not present; no unauthorized animals |
No |
No
|
No |
6-501.111 Keep the premises free of insects, rodents, and other pests. - Observed several flies throughout the facility. |
|
37
|
0
|
Contamination prevented during food preparation, storage and display |
No |
No
|
No |
3-305.11 Store food in a clean, dry location, not exposed to contamination. Keep at least 6 inches above the floor.- Observed items in the walk in freezer stored on the floor. PIC stated the shipment was delivered 30 minutes before the inspection started. EHS observed items still stored on the floor at the end of the inspection. |
|
38
|
0
|
Personal cleanliness |
No |
No
|
No |
2-303.11 Remove jewelry on hands and arms while preparing food. A plain ring, such as a wedding band, is allowed. - Observed an employee working with RTE food, wearing gloves, wearing a watch and bracelet. |
|
42
|
0
|
Utensils, equipment and linens: properly stored, dried and handled |
No |
No
|
No |
4-901.11(A) Air dry equipment and utensils after cleaning and sanitizing.- Observed several stacks of pans stacked wet above the 3-comp sink. |
|
45
|
2
|
Equipment, food and non-food-contact surfaces approved; cleanable, properly designed, constructed and used |
No |
Yes
|
No |
4-501.11 Maintain equipment in good repair. -REPEAT- Observed shelving in the walk in cooler rusting and paint chipping.
4-501.12 Resurface or replace cutting surfaces that can no longer be effectively cleaned and sanitized.- Observed front flip top units, cutting boards, in need of replacing or resurfacing due to deep cuts and grooves. |
|
47
|
0
|
Non-food-contact surfaces clean |
No |
No
|
No |
4-601.11(C )/4-602.13 Keep the equipment clean to avoid build up of dust, food residue or debris.- Observed inside of cold holding equipment and gaskets of those equipment in need of cleaning due to food debris build up. |
|
49
|
0
|
Plumbing installed; proper backflow devices |
No |
No
|
No |
5-205.15 Maintain a plumbing system in good repair.- Observed back hand sink draining slowly. |
|
53
|
0
|
Physical facilities installed, maintained and clean |
No |
No
|
No |
6-501.11 Floors, walls, and ceilings including the attachments such as soap and towel dispensers; light fixtures; and heat/ac vents shall be maintained in good repair. - Observed molding at back can wash in need of replacing.
6-501.12 Floors, walls, ceilings including the attachments such as soap, towel dispensers; light fixtures; and heat/ac vent covers shall be clean. Caution should be used to minimize food exposure.- Observed food debris accumulation throughout the facilities floors. Hard to reach areas behind and underneath equipment are needing of cleaning. |